Please wait a minute...
材料研究学报  2009, Vol. 23 Issue (6): 592-597    
  研究论文 本期目录 | 过刊浏览 |
热镀锌钢材在海洋大气环境中的氢渗透行为
张大磊1;2;  李焰1
1.中国科学院海洋研究所 青岛 266071
2.中国科学院研究生院 北京 100039
Hydrogen permeation of hot-dip galvanized steel exposed to simulated marine atmosphere
Zhang Dalei1;2; Yan LI1
1.Institute of Oceanology; Chinese Academy of Sciences; Qingdao 266071
2.Graduate School; Chinese Academy of Sciences; Beijing 100039
引用本文:

张大磊 李焰. 热镀锌钢材在海洋大气环境中的氢渗透行为[J]. 材料研究学报, 2009, 23(6): 592-597.
, . Hydrogen permeation of hot-dip galvanized steel exposed to simulated marine atmosphere[J]. Chin J Mater Res, 2009, 23(6): 592-597.

全文: PDF(929 KB)  
摘要: 

用改进的Devanathan双面电解池在恒温、恒湿)条件下检测热镀锌钢材的渗氢电流密度并观测其腐蚀形貌, 研究了温度对其氢渗透行为的影响. 结果表明, 在湿度相同的条件下, 随着模拟海洋大气环境温度的升高试样的氢渗透加速, 且湿度越高温度的这种加速作用越显著; 在高温和高湿条件下, 试样的氢吸收和氢渗透进行得更快.

关键词 材料失效与保护  热镀锌镀层   氢吸收  氢渗透 大气腐蚀    
Abstract

Hydrogen permeation behavior of hot-dip galvanized steels exposed to stimulated marine atmospheric environment at different relative humidity and temperature was investigated by hydrogen permeation current measurement using modified Devanathan cell and scanning electron microscopy technique. Influence of temperature on hydrogen permeation process of galvanized steel exposed to simulated marine atmosphere was discussed. The results show that the rate of hydrogen permeation increased gradually with the temperature rising; higher relative humidity stimulated, more obvious hydrogen permeation current; the hydrogen permeation of galvanized steel was the most rapidly when exposed to marine atmospheric environment with high relative humidity and temperature.

Key wordsmaterials failure and protection    hot-dip galvanized coating    hydrogen absorption    hydrogen permeation    atmospheric corrosion
收稿日期: 2009-06-18     
ZTFLH: 

TG174

 
基金资助:

国家自然科学基金40576038、山东省博士基金2006BS07008和山东省自然科学基金Y2008E09资助项目.

1 E.Dubuisson, P.Lavie, F.Dalard, J.P.Caire, S.Szunerits, Corrosion of galvanised steel under an electrolytic drop, Corrosion Science, 49(3), 910-919(2007)
2 G.A.El-Mahdy, A.Nishikata, T.Tsuru, Electrochemical corrosion monitoring of galvanized steel under cyclic wet±dry conditions, Corrosion Science, 42(1), 183-194(2000)
3 E.Dubuisson, P.Lavie, F.Dalard, J.P.Caire, S.Szunerits, Study of the atmospheric corrosion of galvanised steel in a micrometric electrolytic droplet, Electrochemistry Communications, 8(6), 911-915(2006)
4 N.D.Tomashov, Mechanism of electrochemical corrosion of metals under insulating coating. 2. kinetics of cathodic processes on insulated metals in electrolytes, Corrosion, 20(7), T218-&(1964)
5 LI Yan, LIU Meng, ZHANG Yuzhi, ZHANG Dalei, Hydrogen permeation and embrittlement of hot-dip galvanized steel exposed to seawater, The Chinese Journal of Nonferrous Metals, Accepted.
(李 焰, 刘 猛, 张玉志, 张大磊, 热镀锌钢材在海水中的氢渗透行为和脆性研究, 中国有色金属学报, 已录用)
6 S.Oesch, M.Faller, Environmental effects on materials: The effect of the air pollutants SO2, NO2 , NO and O-3 on the corrosion of copper, zinc and aluminum. A short literature survey and results of laboratory exposures, Corrosion Science, 39(9), 1505-1530(1997)
7 Y.Y.Chen, S.C.Chung, H.C.Shih, Studies on the initial stages of zinc atmospheric corrosion in the presence of chloride, Corrosion Science, 48(11), 3547-3564(2006)
8 ZHANG Dalei, LI Yan, Effect of humidity on hydrogen embrittlement susceptivity of hot-dip galvanized steel exposed to simulated marine atmosphere, The Chinese Journal of Nonferrous Metals, Accepted.
(张大磊, 李 焰, 湿度对热镀锌钢材在海洋大气环境中氢脆敏感性的影响, 中国有色金属学报, 已录用)
9 CAOChunan, Natural environmental corrosion of materials in China, (Beijing, Chemical Industrial Press, 2005) p.1
(曹楚南,  中国材料的自然环境腐蚀, (北京, 化学化工出版社, 2005) p.1)
10 D.L.Zhang, Y.Li, Hydrogen permeation characterization of hot-dip galvanized steel in simulated marine atmospheric environment, Advanced Materials Research, 2009, 79-82, Multi-Functional Materials and Structures II:1051-1054
11 D.H.Colemn, B.V.Popov, R.E.White, Hydrogen permeation inhibition by thin layer Zn-Ni alloy electrodeposition, Journal of Applied Electrochemistry, 28(9), 889-894(1998)

12 A.P.Yadav, H.Katayama, K.Noda, H.Masuda, A.Nishikata, T.Tsuru, Surface potential distribution over a zinc/steel galvanic couple corroding under thin layer of electrolyte, Electrochimica Acta, 52(9), 3121-3129(2007)
13 I.Dehri, M.Erbil, The effect of relative humidity on the atmospheric corrosion of defective organic coating materials: an EIS study with a new approach, Corrosion Science, 42(6), 969-978(2000)
14 H.Kim, B.N.Popov, K.S.Chen, Comparison of corrosionresistance and hydrogen permeation properties of Zn-Ni, Zn-Ni-Cd and Cd coatings on low-carbon steel, Corrosion Science, 45(7), 1505-1521(2003)
15 M.Carbucicchio, R.Ciprian, F.Ospitali, G.Palombarini, Morphology and phase composition of corrosion products formed at the zinc-iron interface of a galvanized steel, Corrosion Science, 50(9), 2605-2613(2008)
16 Eiji Tada, Satomi Satoh, Hiroyuki Kaneko, The spatial distribution of Zn2+ during galvanic corrosion of a Zn/steel couple, Electrochimica Acta, 49(14), 2279-2285(2004)
17 A.Tahara, T.Kodama, Potential distribution measurement in galvaniccorrosion of Zn/Fe couple by means of Kelvin probe, Corrosion Science, 42(4), 655-673(2000)

[1] 高巍, 刘江南, 魏敬鹏, 要玉宏, 杨巍. TC4钛合金表面氧化亚铜掺杂微弧氧化层的结构和性能[J]. 材料研究学报, 2022, 36(6): 409-415.
[2] 杨留洋, 谭卓伟, 李同跃, 张大磊, 邢少华, 鞠虹. 利用WBEEIS测试技术对管道缺陷区动态冲刷腐蚀行为的研究[J]. 材料研究学报, 2022, 36(5): 381-391.
[3] 陈铮, 杨芳, 王成, 杜瑶, 卢壹梁, 朱圣龙, 王福会. 惰性无机填料比例和颗粒尺寸对纳米Al/Al2O3 改性有机硅涂料抗高温氧化行为的影响[J]. 材料研究学报, 2022, 36(4): 271-277.
[4] 李玉峰, 张念飞, 刘丽爽, 赵甜甜, 高文博, 高晓辉. 含磷石墨烯的制备及复合涂层的耐蚀性能[J]. 材料研究学报, 2022, 36(12): 933-944.
[5] 陈艺文, 王成, 娄霞, 李定骏, 周科, 陈明辉, 王群昌, 朱圣龙, 王福会. 无机复合涂层对CB2铁素体耐热钢在650℃水蒸气中的防护[J]. 材料研究学报, 2021, 35(9): 675-681.
[6] 唐荣茂, 刘光明, 刘永强, 师超, 张帮彦, 田继红, 甘鸿禹. 用电化学噪声技术研究Q235钢在含氯盐模拟混凝土孔隙液中的腐蚀行为[J]. 材料研究学报, 2021, 35(7): 526-534.
[7] 张大磊, 魏恩泽, 荆赫, 杨留洋, 豆肖辉, 李同跃. 超级铁素体不锈钢表面超疏水结构的制备及其耐腐蚀性能[J]. 材料研究学报, 2021, 35(1): 7-16.
[8] 王冠一, 车欣, 张浩宇, 陈立佳. Al-5.4Zn-2.6Mg-1.4Cu合金板材的低周疲劳行为[J]. 材料研究学报, 2020, 34(9): 697-704.
[9] 黄安然, 张伟, 王学林, 尚成嘉, 范佳杰. 铁素体不锈钢在高温尿素环境中的腐蚀行为研究[J]. 材料研究学报, 2020, 34(9): 712-720.
[10] 公维炜, 杨丙坤, 陈云, 郝文魁, 王晓芳, 陈浩. 扫描电化学显微镜原位观察碳钢涂层缺陷处的交流腐蚀行为[J]. 材料研究学报, 2020, 34(7): 545-553.
[11] 郭铁明, 徐秀杰, 张延文, 宋志涛, 董志林, 金玉花. Q345q桥梁钢和Q345qNH耐候钢在模拟工业大气+除冰盐混合介质中的腐蚀行为[J]. 材料研究学报, 2020, 34(6): 434-442.
[12] 朱金阳, 谭成通, 暴飞虎, 许立宁. 一种新型含AlCr合金钢在模拟油田采出液环境下的CO2腐蚀行为[J]. 材料研究学报, 2020, 34(6): 443-451.
[13] 梁新磊, 刘茜, 王刚, 王震宇, 韩恩厚, 王帅, 易祖耀, 李娜. 氧化石墨烯改性环氧隔热涂层的耐蚀和隔热性能研究[J]. 材料研究学报, 2020, 34(5): 345-352.
[14] 王志虎,张菊梅,白力静,张国君. 水热处理对AZ31镁合金微弧氧化陶瓷层组织结构及耐蚀性的影响[J]. 材料研究学报, 2020, 34(3): 183-190.
[15] 段体岗, 黄国胜, 马力, 彭文山, 张伟, 许立坤, 林志峰, 何华, 毕铁满. Q235/Ni-Co基自修复涂层的制备和耐蚀性能[J]. 材料研究学报, 2020, 34(10): 777-783.