Please wait a minute...
材料研究学报  2014, Vol. 28 Issue (2): 88-92    DOI: 10.11901/1005.3093.2013.378
  本期目录 | 过刊浏览 |
热冲压过程中冷速对高强塑积硼钢性能的影响*
林涛1,宋鸿武1,张士宏1(),程明1,刘伟杰2
1. 中国科学院金属研究所 沈阳 110016
2. 东北大学研究生院 沈阳 110819
Effect of Cooling Rate During Hot Punching on Property of High-performance 22MnB5 Steel Parts
Tao LIN1,Hongwu SONG1,Shihong ZHANG1,**(),Ming CHEN1,Weijie LIU2
1. Institute of Metal Research Chinese Academy of Sciences, Shengyang, 110016
2. Graduate School of Northeastern University, Shenyang, 110819
引用本文:

林涛,宋鸿武,张士宏,程明,刘伟杰. 热冲压过程中冷速对高强塑积硼钢性能的影响*[J]. 材料研究学报, 2014, 28(2): 88-92.
Tao LIN, Hongwu SONG, Shihong ZHANG, Ming CHEN, Weijie LIU. Effect of Cooling Rate During Hot Punching on Property of High-performance 22MnB5 Steel Parts[J]. Chinese Journal of Materials Research, 2014, 28(2): 88-92.

全文: PDF(4848 KB)   HTML
摘要: 

通过对比通有保护气、无保护气、仿工业化热冲压的热冲压件的性能, 研究了热冲压过程中冷速对硼钢22MnB5组织性能的影响规律。结果表明, 在三种工艺条件下实验件的冷却速度均大于马氏转变的临界冷却速度, 组织均为板条状马氏体, 抗拉强度在1500 MPa以上。冲压模具的温度升高, 板料表面存在氧化皮, 都会使板料的冷却速度减小, 马氏体片层变粗, 性能下降。通过降低模具温度, 增加板料加热时的起保护, 可使得板料冷速增加, 马氏体组织细小, 获得强度为1600 MPa以上, 强塑积接近20, 000 MPa%的热冲压硼钢件。

关键词 金属材料热冲压气体保护冷却速度强塑积    
Abstract

The effect of cooling rate during punching process on the microstructure and mechanical property of the 22MnB steel was investigated by three different processing conditions i.e. the processes with and without argon protection as well as a simulated industrial process. The results show that the cooling rates of all the hot punched parts with the three different processing conditions are higher than the critical cooling rate of 22MnB5 steel, thus the hot punched steels with a microstructure of lath martensite exhibit tensile stresses higher than 1500 MPa. When the temperature of hot punch tools is higher, an oxide scale appeared on the punched workpiece surface, thereby, the cooling rate and the mechanical property of the steel become lower, and the martensitic plate becomes thicker. The hot punched part with tensile strength about 1600 MPa and strength multiplied ductility c.a. 20, 000 MPa% was available by heating with argon protection while reducing the initial temperature of punch tools to ambient temperature. This is because the cooling rate of the punched part was high and thereby the martensite plates of the steel became fine for the process with protective gas.

Key wordsmetallic materials    hot punching    gas-protection    cooling rate    strength multiplied ductility
收稿日期: 2013-06-04     
基金资助:* 国家自然科学基金51034009 项目资助。
作者简介:

本文联系人: 张士宏, 研究员

Mat. C Si Mn Cr Ti B
22MnB 0.23 0.25 1.20 0.18 0.03 0.003
表1  实验钢22MnB5化学成分
Fig.1  板料的组织和尺寸
图2  热冲压实验设备
Gas protection for the heated blank The temperature of the dies
Process 1 Yes Room Temperature
Process 2 No Room Temperature
Process 3 Yes 300℃
表2  三种工艺的参数
图3  冲压后的板料与拉伸试样尺寸(mm)
图4  三种工艺冲板的温度历程曲线
图5  冲压件的力学性能
图6  三种工艺热冲件的组织
图7  用通保护气热冲压(工艺1(a))与未通保护气热冲压(工艺2(b))试制的盒型件
1 H. Karbasian, A. E. Tekkaya,A review on hot stamping, Journal of Materials Processing Technology, 210(15), 2103-2118(2010)
2 M. Naderi, V. Uthaisangsuk, U. Prahl, W. Bleck,A numerical and experimental investigation into hot stamping of boron alloyed heat treated steels, Steel Research Int., 79(2), 77-84(2008)
3 WANG Cunyu,SHI Jie, HUI Weijun, CHEN Ying, ZHANG Yingjian, DONG Han, Process research on improving hot stamping steel ductility, Forging & Stamping Technology, 36(2), 128-130(2011)
3 (王存宇, 时 捷, 惠 卫, 军陈鹰, 张英建, 董 瀚, 提高热成形钢塑性的工艺研究, 锻压技术, 36(2), 128-130(2011))
4 M. Geiger, M. Merklein, C. Hoff,Basic investigations on the hot stamping steel 22MnB5, in: Processing of Sheet Metal 2005, M.Geiger. Editors, 2005: 795-802
5 K. Mori, S. Maki, Y. Tanaka,Warm and hot stamping of ultra high tensile strength steel sheets using resistance heating, Annals of the CIRP, 54(1), 209–212(2005)
6 K. Mori, S. Saito, S. Maki,Warm and hot punching of ultra high strength steel sheet, Cirp Annals-Manufacturing Technology, 57(1), 321-324(2008)
7 A. Tmetta, S. Bruschi, A. Ghiotti. Investigation of 22MnB5 formability in hot stamping operations, Journal of Materials Processing Technology, 177(1/3), 396-400(2006)
8 Xing Zhongwen,Bao Jun, Yang Yuying, Zhong Chaoting, Hot stamping processing experiments of quenchable boron steel, Materials Science and Technology, 16(2), 172-175(2008)
8 (邢忠文, 包 军, 杨玉英, 钟朝廷, 可淬火硼钢板热冲压成形实验研究, 材料科学与工艺, 16(2), 172-175(2008))
9 Liu Wei,Liu Hongshen, Xing Zhongwen, Liu Gang, Bao Jun, Effect of tool temperature and punch speed on hot stamping of ultra-high strength steel, Transactions of Nonferrous Metals Society of China, 22(z2), s534-s541(2012)
10 Liu Hongsheng,Xing Zhongwen, Lei Chengxi, Hot formation quality of high strength steel BRl500HS for hot stamping without cooling system, Transactions of Nonferrous Metals Society of China, 22(z2), s542-s547(2012)
11 H. Hoffmann, H. So,H Steinbeiss, Design of hot stamping tools with cooling system, Annals of the CIRP, 56(1), 269-272(2007)
12 T Svec, M Grüner, M Merklein. FE-simulation of the heat transfer by defined cooling conditions during the hot stamping process, Key Engineering Materials, 473, 699-706(2011)
13 Jiang Chao,Shan Zhongde, Zhuan Bailiang, Rong Wenjuan, Zhang Milan, Microstructure and properties of hot stamping 22MnB5 steel, Transactions of Materials and Heat Treatment, 33(3), 78-81(2012)
13 (姜 超, 单忠德, 庄百亮, 戎文娟, 张密兰, 热冲压成形22MnB5钢板的组织和性能, 材料热处理学报, 33(3), 78-81(2012))
14 Lu Jun,Zeng Xiaoqin, Ding Wenjiang, The Hall-Petch relationship, Light Metals, 8, 59-64(2008)
14 (路 君, 曾小勤, 丁文江, 晶粒度与合金强度关系, 轻金属, 8, 59-64(2008))
15 S. Moritoa, H. Yoshidab, T. Makic, X. Huangd,Effect?of?block?size on?the?strength?of?lath martensite in low carbon steels, Material Science Engineering: A, 438-440, 237-240(2006)
[1] 毛建军, 富童, 潘虎成, 滕常青, 张伟, 谢东升, 吴璐. AlNbMoZrB系难熔高熵合金的Kr离子辐照损伤行为[J]. 材料研究学报, 2023, 37(9): 641-648.
[2] 宋莉芳, 闫佳豪, 张佃康, 薛程, 夏慧芸, 牛艳辉. 碱金属掺杂MIL125CO2 吸附性能[J]. 材料研究学报, 2023, 37(9): 649-654.
[3] 赵政翔, 廖露海, 徐芳泓, 张威, 李静媛. 超级奥氏体不锈钢24Cr-22Ni-7Mo-0.4N的热变形行为及其组织演变[J]. 材料研究学报, 2023, 37(9): 655-667.
[4] 邵鸿媚, 崔勇, 徐文迪, 张伟, 申晓毅, 翟玉春. 空心球形AlOOH的无模板水热制备和吸附性能[J]. 材料研究学报, 2023, 37(9): 675-684.
[5] 幸定琴, 涂坚, 罗森, 周志明. C含量对VCoNi中熵合金微观组织和性能的影响[J]. 材料研究学报, 2023, 37(9): 685-696.
[6] 欧阳康昕, 周达, 杨宇帆, 张磊. LPSOMg-Y-Er-Ni合金的组织和拉伸性能[J]. 材料研究学报, 2023, 37(9): 697-705.
[7] 徐利君, 郑策, 冯小辉, 黄秋燕, 李应举, 杨院生. 定向再结晶对热轧态Cu71Al18Mn11合金的组织和超弹性性能的影响[J]. 材料研究学报, 2023, 37(8): 571-580.
[8] 熊诗琪, 刘恩泽, 谭政, 宁礼奎, 佟健, 郑志, 李海英. 固溶处理对一种低偏析高温合金组织的影响[J]. 材料研究学报, 2023, 37(8): 603-613.
[9] 刘继浩, 迟宏宵, 武会宾, 马党参, 周健, 徐辉霞. 喷射成形M3高速钢热处理过程中组织的演变和硬度偏低问题[J]. 材料研究学报, 2023, 37(8): 625-632.
[10] 由宝栋, 朱明伟, 杨鹏举, 何杰. 合金相分离制备多孔金属材料的研究进展[J]. 材料研究学报, 2023, 37(8): 561-570.
[11] 任富彦, 欧阳二明. g-C3N4 改性Bi2O3 对盐酸四环素的光催化降解[J]. 材料研究学报, 2023, 37(8): 633-640.
[12] 王昊, 崔君军, 赵明久. 镍基高温合金GH3536带箔材的再结晶与晶粒长大行为[J]. 材料研究学报, 2023, 37(7): 535-542.
[13] 刘明珠, 樊娆, 张萧宇, 马泽元, 梁城洋, 曹颖, 耿仕通, 李玲. SnO2 作散射层的光阳极膜厚对量子点染料敏化太阳能电池光电性能的影响[J]. 材料研究学报, 2023, 37(7): 554-560.
[14] 秦鹤勇, 李振团, 赵光普, 张文云, 张晓敏. 固溶温度对GH4742合金力学性能及γ' 相的影响[J]. 材料研究学报, 2023, 37(7): 502-510.
[15] 刘天福, 张滨, 张均锋, 徐强, 宋竹满, 张广平. 缺口应力集中系数对TC4 ELI合金低周疲劳性能的影响[J]. 材料研究学报, 2023, 37(7): 511-522.