Please wait a minute...
材料研究学报  2013, Vol. 27 Issue (5): 469-476    
  研究论文 本期目录 | 过刊浏览 |
发动机用灰铸铁的低周疲劳行为*
袁永立1 何国球1 樊康乐1 刘晓山1 朱旻昊2
1. 同济大学材料科学与工程学院 上海市金属功能材料开发应用重点实验室 上海 201804
2. 西南交通大学 牵引动力国家重点实验室 成都 610031
Low Cycle Fatigue Behavior of Gray Cast Iron Used for Engine
YUAN Yongli1 HE Guoqiu1** FAN Kangle1 LIU Xiaoshan1 ZHU Minhao2
1. School of Materials Science and Engineering, Tongji University, Shanghai Key Laboratory for R&D and Application of Metallic Functional Materials, Shanghai 201804
2. Nation Traction Power Laboratory, Southwest Jiaotong University, Chengdu 610031
引用本文:

袁永立, 何国球, 樊康乐, 刘晓山, 朱旻昊. 发动机用灰铸铁的低周疲劳行为*[J]. 材料研究学报, 2013, 27(5): 469-476.
YUAN Yongli, HE Guoqiu, FAN Kangle, LIU Xiaoshan, ZHU Minhao. Low Cycle Fatigue Behavior of Gray Cast Iron Used for Engine[J]. Chinese Journal of Materials Research, 2013, 27(5): 469-476.

全文: PDF(6819 KB)  
摘要: 

研究了发动机缸体用灰铸铁材料在室温、150℃和250℃下的低周疲劳行为。根据对拉伸应力-应变、循环应力-应变和应变-疲劳寿命数据的分析, 给出了疲劳参数。结果表明: 在高温下灰铸铁的弹性模量、强度降低, 延伸率增大; 循环应力响应表明, 在较小的应变幅下经历初期循环硬化、循环软化、断裂, 而在高温和较大应变幅下几乎没有硬化阶段, 循环软化至断裂; 其室温疲劳寿命最长, 150℃最短, 250℃居中。微观分析结果表明: 疲劳裂纹萌生于片状石墨尖端、夹杂物及孔洞处, 沿石墨扩展, 夹杂物导致分支裂纹及裂纹偏转, 延缓裂纹的扩展; 灰铸铁的疲劳断裂方式为沿晶和准解理断裂的复合机制, 存在扇形解理面和二次裂纹, 解理台阶上观察到疲劳条带和韧窝。

关键词 金属材料灰铸铁低周疲劳循环应力响应疲劳裂纹疲劳断裂    
Abstract

Low cycle fatigue (LCF) behaviors of grey cast iron used for cylinder were investigated at room temperature (RT), 150℃ and 250℃. Tensile stress-strain curves, cyclic stress-strain curves and fatigue life curves were obtained. The results show that Young’s Modulus, proof strength and ultimate tensile strength of grey cast iron decreased with increasing temperature, while the elongation increased. Cyclic hardening/softening exhibited cyclic hardening initially, then softening and fracture at lower strain amplitudes, while it exhibited cyclic softening and fracture directly without cyclic hardening at 150℃, 250℃ and higher strain amplitudes. Fatigue life decreased with the increase of temperature and was lowest at 150℃. LCF cracks initiated predominantly at the flake graphite tip, near-surface defects such as inclusions and voids, and crack would propagate along graphite. Heterogeneous inclusions contributed crack deflection and bifurcation which would decrease the propagating rate. Crack propagation was mainly characterized by fan shaped cleavage plane, secondary cracks, fatigue striation and some dimples, which indicated the fractural mechanism is intergranular and quasi-cleavage cracks.

Key wordsmetallic materials    gray cast iron    low cycle fatigue    cyclic stress response    fatigue crack    fatigue fracture
    
ZTFLH:  TG251  
[1] 毛建军, 富童, 潘虎成, 滕常青, 张伟, 谢东升, 吴璐. AlNbMoZrB系难熔高熵合金的Kr离子辐照损伤行为[J]. 材料研究学报, 2023, 37(9): 641-648.
[2] 宋莉芳, 闫佳豪, 张佃康, 薛程, 夏慧芸, 牛艳辉. 碱金属掺杂MIL125CO2 吸附性能[J]. 材料研究学报, 2023, 37(9): 649-654.
[3] 赵政翔, 廖露海, 徐芳泓, 张威, 李静媛. 超级奥氏体不锈钢24Cr-22Ni-7Mo-0.4N的热变形行为及其组织演变[J]. 材料研究学报, 2023, 37(9): 655-667.
[4] 邵鸿媚, 崔勇, 徐文迪, 张伟, 申晓毅, 翟玉春. 空心球形AlOOH的无模板水热制备和吸附性能[J]. 材料研究学报, 2023, 37(9): 675-684.
[5] 幸定琴, 涂坚, 罗森, 周志明. C含量对VCoNi中熵合金微观组织和性能的影响[J]. 材料研究学报, 2023, 37(9): 685-696.
[6] 欧阳康昕, 周达, 杨宇帆, 张磊. LPSOMg-Y-Er-Ni合金的组织和拉伸性能[J]. 材料研究学报, 2023, 37(9): 697-705.
[7] 徐利君, 郑策, 冯小辉, 黄秋燕, 李应举, 杨院生. 定向再结晶对热轧态Cu71Al18Mn11合金的组织和超弹性性能的影响[J]. 材料研究学报, 2023, 37(8): 571-580.
[8] 熊诗琪, 刘恩泽, 谭政, 宁礼奎, 佟健, 郑志, 李海英. 固溶处理对一种低偏析高温合金组织的影响[J]. 材料研究学报, 2023, 37(8): 603-613.
[9] 刘继浩, 迟宏宵, 武会宾, 马党参, 周健, 徐辉霞. 喷射成形M3高速钢热处理过程中组织的演变和硬度偏低问题[J]. 材料研究学报, 2023, 37(8): 625-632.
[10] 由宝栋, 朱明伟, 杨鹏举, 何杰. 合金相分离制备多孔金属材料的研究进展[J]. 材料研究学报, 2023, 37(8): 561-570.
[11] 任富彦, 欧阳二明. g-C3N4 改性Bi2O3 对盐酸四环素的光催化降解[J]. 材料研究学报, 2023, 37(8): 633-640.
[12] 王昊, 崔君军, 赵明久. 镍基高温合金GH3536带箔材的再结晶与晶粒长大行为[J]. 材料研究学报, 2023, 37(7): 535-542.
[13] 刘明珠, 樊娆, 张萧宇, 马泽元, 梁城洋, 曹颖, 耿仕通, 李玲. SnO2 作散射层的光阳极膜厚对量子点染料敏化太阳能电池光电性能的影响[J]. 材料研究学报, 2023, 37(7): 554-560.
[14] 秦鹤勇, 李振团, 赵光普, 张文云, 张晓敏. 固溶温度对GH4742合金力学性能及γ' 相的影响[J]. 材料研究学报, 2023, 37(7): 502-510.
[15] 刘天福, 张滨, 张均锋, 徐强, 宋竹满, 张广平. 缺口应力集中系数对TC4 ELI合金低周疲劳性能的影响[J]. 材料研究学报, 2023, 37(7): 511-522.