|
|
Preparation and Performance of SiC Foam Ceramic/Fe Matrix Co-continuous Phase Composites |
Zhiheng REN,Peng JIN,Xiaoming CAO,Jinsong ZHANG( ) |
Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016 |
|
Cite this article:
Zhiheng REN,Peng JIN,Xiaoming CAO,Jinsong ZHANG. Preparation and Performance of SiC Foam Ceramic/Fe Matrix Co-continuous Phase Composites. Chinese Journal of Materials Research, 2014, 28(11): 814-820.
|
Abstract SiC foam ceramic/Fe based co-continuous phase composites were prepared by squeeze casting method using oxidized SiC foam ceramic. Then the prepared composites were annealed. The influence of preparation process and SiC volume fraction on microstructures and mechanical properties of the composites were investigated. Results show that a SiO2 barrier film of 1 mm in thickness on the surfaces of SiC foam can form after oxidizing at 1250°C for 48 h, which then can efficiently prevent the formation of a brittle intermetallic compound Fe3Si at the interface of Fe matrix and SiC during the preparation of composites. As a result, the flexural strength of composites was increased by 100% and compressive strength by 18%. The thickness of SiO2 film was increased after oxidizing at 1250°C for 72 h, and a thicker SiO2 film may induce mismatch of thermal expansion coefficient between SiO2, Fe and SiC, which thereby resulted in the increase of residual stress. Therefore, the mechanical properties of composites were decreased slightly. The residual stress could be relieved after annealing of composites at 600°C for 4 h, which improved the mechanical properties of composites. The function of bridging and deflecting crack of metal matrix is big for the composite with small SiC volume fraction, which is in turn beneficial to the enhancement of the flexural strength and flexural strain. For the composite with the higher SiC volume fraction, the size of SiC skeleton became bigger and the load-carrying capacity was strengthened, thereby its compressive strength was increased.
|
Received: 28 May 2014
|
Fund: *Supported by National High Technology Research and Development Program of China No.2012AA03A508. |
1 | CHEN Weiping,YANG Shaofeng, HAN Mengyan, Research development of ceramic/Fe-based alloy composites, The Chinese Journal of Nonferrous Metals, 20(2), 257(2010) | 1 | (陈维平, 杨少锋, 韩孟岩, 陶瓷/铁基合金复合材料的研究进展, 中国有色金属学报, 20(2), 257(2010)) | 2 | NIE Cunzhu,ZHAO Naiqin, Review of metal-matrix composite materials for electronic packaging, Heat Treatment of Metals, 28(6), 1(2003) | 2 | (聂存珠, 赵乃勤, 金属基电子封装复合材料的研究进展, 金属热处理, 28(6), 1(2003)) | 3 | HAN Hui,LI Jun, JIAO Lijuan, LI Nan, Study on the application of ceramic-metal composite materials in bulletproof field, Materials Review, 21(2), 34(2007) | 3 | (韩 辉, 李 军, 焦丽娟, 李 楠, 陶瓷-金属复合材料在防弹领域的应用研究, 材料导报, 21(2), 34(2007)) | 4 | D. R. Clarke,Interpenetrating phase composites, Journal of the American Ceramic Society, 75(4), 739(1992) | 5 | C. San Marchi, M. Kouzeli, R. Rao, J. A. Lewis, D. C. Dunand,Alumina–aluminum interpenetrating-phase composites with three-dimensional periodic architecture, Scripta Materialia, 49(9), 861(2003) | 6 | M. L. Young, J. D. Almer, U. Lienert, D. R. Haeffner, R. Rao, J. A. Lewis, D. C. Dunand,Diffraction measurements of load transfer in interpenetrating-phase Al2O3/Al composites, in: Affordable Metal Matrix Composites for High-Performance Applications, edited by A. B. Pandey, K. L. Kending, T. J. Watson (Pennsylvania, TMS, 2003)p.225 | 7 | XIE Sujing,CAO Xiaoming, ZHANG Jinsong, LI Shu, LIU Yang, Effect of 3D-meshy SiC on the dry friction and wear of aluminum alloys, Chinese Journal of Materials Research, 17(1), 10(2003) | 7 | (谢素菁, 曹小明, 张劲松, 李 曙, 刘 阳, 三维网络SiC对铝合金干摩擦磨损性能的影响, 材料研究学报, 17(1), 10(2003)) | 8 | XING Hongwei,CAO Xiaoming, HU Wanping, TIAN Chong, ZHAO Longzhi, ZHANG Jinsong, Solidification microstructure of 3D-meshy SiC/Cu metal matrix composites, Chinese Journal of Materials Research, 18(6), 597(2004) | 8 | (邢宏伟, 曹小明, 胡宛平, 田 冲, 赵龙志, 张劲松, 三维网络SiC/Cu金属基复合材料的凝固显微组织, 材料研究学报, 18(6), 597(2004)) | 9 | S. Sharma,N. E. Rayess, N. Dukhan, Preliminary Nvh characterization of metal foam-polymer interpenetrating phase composites, in: Proceedings of the ASME International Mechanical Engineering Congress and Exposition 2009 (New York, ASME, 2010)p.445 | 10 | FENG Shengshan,WANG Zejian, LIU Qingfeng, XU Shunhong, LI Jinshan, WANG Cungui, Damping characteristics of three-dimensional co-continuous network SiC/cast iron composites, Foundry Equipment and Technology, (4), 7(2009) | 10 | (冯胜山, 王泽建, 刘庆丰, 许顺红, 李金山, 王存贵, 三维连续网络结构碳化硅铸铁铸态复合材料的减振性能, 铸造设备与工艺, (4), 7(2009)) | 11 | FENG Shengshan,WANG Zejian, LIU Qingfeng, YANG Zongming, Friction and abrasion characteristics of three-dimensional co-continuous network SiC/cast iron composites, Foundry Technology, 31(1), 56(2010) | 11 | (冯胜山, 王泽建, 刘庆丰, 杨宗明, 三维连续网络结构碳化硅/铸铁复合材料的摩擦磨损性能, 铸造技术, 31(1), 56(2010)) | 12 | WEI Wentao,The preparation, microstructure and properties of the new type 3D-meshy SiC/Cu-Fe composite material, Master’s Dissertation (Northeastern University, 2009) | 12 | (魏文韬, 新型三维网络SiC/Cu-Fe复合材料的制备、组织与性能, 硕士学位论文 (东北大学, 2009)) | 13 | W. M. Tang, Z. X. Zheng, H. F. Ding, Z. H. Jin,Control of the interface reaction between silicon carbide and iron, Materials Chemistry and Physics, 80(1), 360(2003) | 14 | B. S. Terry, O. S. Chinyamakobvu,Assessment of the reaction of SiC powders with iron-based alloys, Journal of Materials Science, 28(24), 6779(1993) | 15 | TANG Wenming,ZHENG Zhixiang, DING Houfu, JIN Zhihao, Progress in studies of the interface reaction and the interface optimization of Fe/SiC system, Ordnance Material Science and Engineering, 22(4), 64(1999) | 15 | (汤文明, 郑治祥, 丁厚福, 金志浩, Fe/SiC界面反应机理及界面优化工艺研究的进展, 兵器材料科学与工程, 22(4), 64(1999)) | 16 | TANG Wenming,ZHENG Zhixiang, DING Houfu, JIN Zhihao, Oxidation of SiC and its effect on the interface stability of SiC/Fe, Journal of Inorganic Materials, 16(2), 289(2001) | 16 | (汤文明, 郑治祥, 丁厚福, 金志浩, SiC表面氧化及其对SiC/Fe界面稳定性的影响, 无机材料学报, 16(2), 289(2001)) | 17 | SHI Lei,LIU Junwu, WANG Zhixiang, WANG Xiang, ZHENG Zhixiang, The effect of coated SiC powders on the sintering and mechanical properties of the SiCp/Fe composites, Journal of Hefei University of Technology, 23(2), 177(2000) | 17 | (石 磊, 刘君武, 王支相, 汪 翔, 郑治祥, SiC颗粒表面改性对SiCp/Fe烧结及性能的影响, 合肥工业大学学报(自然科学版), 23(2), 177(2000)) | 18 | WANG Zejian,Study on the preparation and properties of three-dimensional co-continuous network SiC/Cast iron composites, Master Dissertation (Hubei University of Technology, 2009) | 18 | (王泽建, 三维连续网络结构碳化硅陶瓷/铸铁复合材料的制备方法及性能研究, 硕士学位论文 (湖北工业大学, 2009)) | 19 | M. Hoffman, S. Skirl, W. Pompe, J. Rodel,Thermal residual strains and stresses in Al2O3/Al composites with interpenetrating networks, Acta Materialia, 47(2), 565(1999) | 20 | P. Agrawal, K. Conlon, K. J. Bowman, C. T. Sun, F. R. Cichocki, Jr., K. P. Trumble,Thermal residual stresses in co-continuous composites, Acta Materialia, 51(4), 1143(2003) | 21 | ZHANG Jinsong,CAO Xiaoming, TIAN Chong, HU Wanping, YANG Yongjin, Compact foamy thyrite in high intensity and preparation method, China patent, CN1600742A (2005) | 21 | (张劲松, 曹小明, 田 冲, 胡宛平, 杨永进, 一种高强度致密的泡沫碳化硅陶瓷材料及其制备方法, 中国专利, CN1600742A(2005)) | 22 | ZHENG Chuanwei,High temperature oxidation behavior of several silicon carbide ceramics processed by reaction bonding method, PhD Dissertation (Institute of Metal Research, Chinese Academy of Sciences, 2009) | 22 | (郑传伟, 几种反应烧结碳化硅陶瓷材料的高温氧化行为研究, 博士学位论文 (中国科学院金属研究所, 2009)) | 23 | C. Zheng, Z. Yang, J. Zhang,The high-temperature oxidation behavior of reaction-bonded porous silicon carbide ceramics in dry oxygen, Journal of the American Ceramic Society, 93(7), 2062(2010) | 24 | ZHANG Guoding,Interfaces in metal matrix composites, Chinese Journal of Materials Research, 11(6), 649(1997) | 24 | (张国定, 金属基复合材料界面问题, 材料研究学报, 11(6), 649(1997)) | 25 | CUI Chunxiang,WU Renjie, WANG Haowei, Characteristics of interface and mechanical properties of MMCs, Aerospace Materials & Technology, 1(1997) | 25 | (崔春翔, 吴人杰, 王浩伟, 金属基复合材料界面特征与力学性能, 航空材料工艺, 1(1997)) | 26 | FAN Dongli, PAN Jiansheng, XU Yueming, TONG Xiaohui, China Materials Engineering Canon (Vol.15) (Beijing, Chemical Industry Press, 2005) p.249 | 26 | (249) | 27 | ZHENG Chuanwei,YANG Zhenming, TIAN Chong, CAO Xiaoming, ZHANG Jinsong, Oxidation characteristics of silicon carbide foam ceramic at elevated temperature, Rare Metal Materials and Engineering, 38(z3), 289(2009) | 27 | (郑传伟, 杨振明, 田 冲, 曹小明, 张劲松, SiC泡沫陶瓷材料的高温氧化行为, 稀有金属材料与工程, 38(z3), 289(2009)) |
|
No Suggested Reading articles found! |
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
|
Shared |
|
|
|
|
|
Discussed |
|
|
|
|